Use LEFT and RIGHT arrow keys to navigate between flashcards;
Use UP and DOWN arrow keys to flip the card;
H to show hint;
A reads text to speech;
128 Cards in this Set
- Front
- Back
How can the manufacturer date of ordinance be determined? |
Lot number. |
|
What are the 2 types of practice bombs? |
Full-scale and subcaliber. |
|
What type of fuze is an FMU-139 series fuze? |
Electronic. |
|
What is the purpose of the MK-122 safety switch? |
Provides a path for the aircraft to power the fuse and provides RADHAZ protection while outside of the assembly area. |
|
Which bomb bodies way 500 pounds? |
MK-82 / BLU-111 / BLU-126 |
|
Which bomb bodies weight a 1000 pounds? |
MK-83 / BLU-110 |
|
Which bomb bodies way 2000 pounds? |
MK-84, BLU-109, BLU-116, BLU-117 |
|
What do the yellow bands on the bomb indicate? |
1 yellow band = high explosive, 2 yellow bands = thermally protected, 3 yellow bands = intensive munitions, 4 yellow bands = low collateral damage
|
|
Approximately what percentage of a bomb body's weight is explosive filler? |
45%. |
|
What is the normal height of burst for the DSU-33 proximity sensor? |
20 feet |
|
What will be visible in the observation window of the DSU-33 if the battery has not been activated? |
White or light Grey |
|
What tail assembly is used to build a GBU-38? |
K M U-572 |
|
What tail kit/components are used to build a GBU-12. |
MXU-650 Series |
|
The BLU-126 uses what type of suspension lug? |
MS3314 |
|
How much space is acceptable between the bomb fuze well and proximity sensor? |
1/4" |
|
Which spotting charges shall be immersed in water when defects or leakage is observed/detected? |
C X U 3 and C X U 4 |
|
Which bombbody has a thermoplastic ring in the nose fuse wealth? |
BLU-111 C. B. |
|
What is the allowable limitation of missing thermal coating on thermally protected bomb bodies? |
15 SQ/IN in one area. 56 SQ/IN in overall |
|
What explosive filler is used in MK/BLU series bombs bodies? |
H6 / PBXN-109 |
|
What initiator is used with the FMU-143 fuze? |
FZU-32 |
|
What does JDAM stand for |
Joint direct attack munitions. |
|
What is the EEA for the FMU-139? |
Gag rod Extended with red and black stripes visible. |
|
What is the EEA for FMU-140? |
Nipple extention with red visible |
|
What is the EEA for FMU-143? |
Gag rod Protruding. |
|
Who must be notified in the event a fuze is found to be armed or partially armed. |
Proper authoritie / EOD |
|
What does EEA stand for? |
External evidence of arming |
|
What is the EEA for the MK-339? |
Has red pin protruding through green foil |
|
What is a warning? |
Can cause death or serious injury to personnel or damage equipment? |
|
What is a caution? |
Can cause serious injury or damage to equipment? |
|
What is a note? |
To emphasize the Step. |
|
What is hero? |
Hazards of electric magnetic radiation to ordinance. |
|
Where are the safety rules And. precautions posted for each magazine? |
On the inside front wall or front door. |
|
How can you identify Corrosion on aluminum. |
White or Gray powder. |
|
How is ordinance on skids (rolling stock) parked? |
Parked fwd to aft Chain down and handles removed. |
|
Which areas do you not stand in relation to forward firing ordinance? |
Never stand directly in front or behind forward fire and ordinance. |
|
Who can stop an ordinance evolution? |
Anyone |
|
What is the minimum number personnel to move ordinance? |
4 personnel, 1 quaso, 1 team leader, 2 team members. |
|
Who is in charge Regardless of rank during ordinance evolution? |
Team leader |
|
What event led to the Ordinance qualified program being established? |
An explosive mishap on board the USS Oriscany in 1966 resulting in significant loss of life and major ship damage. |
|
What is the drop criteria for rocket motors to be deemed NRFI? |
Any distance |
|
What hazard is associated with a rocket that potentially has cracked propellant grain? |
Uneven burn, that cause pressure beyond limits, resulting in Premature detonation. |
|
What is the safe working load for elevators on board JCS? |
10,500 pounds. |
|
What is the stacking height on the elevator platform on board JCS? |
72 inches. |
|
How much does AEE weigh? |
7200 pounds. |
|
What is the safe working load for A EE forklift? |
4500 pounds. |
|
20mm Ammunition falls under what QUAL/CERT family group? |
Gun ammunition (fixed gun) |
|
20mm Tracer rounds are Visible for approxim What distance of flight? |
128 yards / 1170 meters |
|
What are dummy rounds used for? |
Drills, Maintenance and Testing |
|
How is 20mm primed? |
Electrically |
|
What does LALS stand for? |
Linkless Ammunition Loading System |
|
How many rounds does a LALS hold? |
1800 rounds |
|
How can you identify different 20mm configurations? |
Color and lettering on the projectile |
|
What round has a blue projectile with white markings and orange T? |
Target practice, tracer |
|
What is the designating for the point detonating fuze? |
M 505 A3 |
|
What can be used to manually lift a MK-82 bomb body? |
H L U-256 hoisting bar |
|
How many lifting points are on the MK-51 weapons carrier? |
8 |
|
What is the safe working load of the MK-49? |
2500 pounds |
|
What is the safe working load of the 12c? |
1250 pounds |
|
What is the safe working load of the MHU-191? |
5000 pounds |
|
What hoisting beam is used to remove AIM-120 missile from their container? |
MK-24 mod 0, or H L U-421/E |
|
What hoist adapter is used when utilizing a forklift? |
MK 91 mod 0 Hook Adapter |
|
What is the purpose of the EMCON bill? |
To provide directions for implementing HERO restrictions. |
|
What is the HERO publication? |
NAVSEA OP 3565 |
|
AGM-88 HARM missile utilizes what launcher? |
LAU-118 |
|
What is the AGM-84 and what does it stand for? |
SLAM-ER; StandOff Land Attack Missile Expanded Response |
|
What type of missile is the AGM-88 (HARM) |
Air-to-Ground, SuperSonic, Anti-Radiation Missile |
|
What is the AGM-154 and what does it stand for? |
JSOW; JOINT STAND OFF WEAPON |
|
What does CATM stand for? |
Captive Air Training Missile |
|
What does DATM stand for? |
Dummy Air Training Missile |
|
What does PASE stand for? |
Preloaded Accessory Suspension Equipment |
|
What does intent to launch mean? |
Was intended and aborted by air crew or failed prior to separation |
|
What does TIVS stand for? |
Thermally initiated venting system |
|
What is the degree of heat and duration that TIVS will initiate? |
350* for 8 hours or 550* for 30 sec |
|
What air launched missile would you find TIVS on? |
AIM-120 AMRAAM |
|
What does CMBRE stand for? |
Common Munitions Built-in-Test Reprogramming Equipment |
|
What does PCMIA stand for? |
Personal computer memory card international association |
|
How long is a self test on the CMBRE+ good for? |
24 hours |
|
Which slot if the maintenance card inserted into the CMBRE? |
The lower slot |
|
How many boxes are included with the CAMBRE? |
3 boxes |
|
What are the contents of the 3 CAMBRE boxes? |
1 Test Adapter 2 Computer, Cables 3 CD Drive, Floppy Disc's |
|
Where is the EEA on a AGM-65 Maverick? |
Safe arm key underside of missile |
|
What is the weapons assembly manual for general purposes bombs. |
11-140-5 |
|
What pub is storage and handling afloat? |
OP 4 |
|
What is the Air-to-Air pub? |
11-140-6.1 |
|
All DON personnel that handle our physically interact with Ammunition and explosive must be qualified according to what publication? |
OPNAVINST 8023.24 |
|
OPNAV 8023.24 Governs what program |
QUAL/CERT |
|
What is the work task code for testing? |
WTC 6 |
|
What is work task code 1? |
Handling |
|
What is the preferred method of training? |
OJT |
|
What publication is referred to as being written in blood and contains lessons learned? |
SWO20-AD-SAF-010 |
|
What is the weapons manual for pyrotechnics? |
11-140-7 |
|
What is the AWSE pub? |
11-140-25 |
|
Air-to-Ground missile and PASE weapons publication? |
11-140-6.2 |
|
What pub is for CATM, NATM, and DATM? |
11-140-6.3 |
|
What publication is for cluster bombs and PDU-5? |
11-140-9 |
|
GBU Pub? |
11-140-10 |
|
What pub is used for JDAM? |
11-140-10 |
|
What pub is used for 20mm? |
11-140-119 |
|
What pub is used for Airborne Bomb and rocket fuze? |
11-1F-2 |
|
Ordnance corrosion pub |
01-1A-75 |
|
What is the burn time for a MK-58 marine located marker? |
40-60 min |
|
What launchers fire 2.75" rockets? |
LAU-61 & LAU-68 |
|
What are rockets built on when afloat? |
AERO 71 Flatbed |
|
What does APKWS stand for? |
Advance Precision kill weapons System |
|
How long is a LAU-61/68 electrical test valid for? |
30 days |
|
Can a rocket launcher be tested with rockets loaded? |
Hell no |
|
A LAU-68 may have how many tubes inoperable and still be RFI? |
1 |
|
A LAU-61 can have how many tubes inoperable? |
3 |
|
What color is the blast paddle painted when a tube is deemed inoperable? |
Red |
|
A LAU-68 can hold how many rockets? |
7 |
|
A LAU-61 holds how many rockets? |
19 |
|
What are the sprinkler systems designed to do? |
Limit the spread, and if possible, suppress/ extinguish the fire. |
|
What are the 3 types of remote operation? |
Manual Hydraulic Automatic |
|
What is the purpose of the HSD? |
To activate the sprinkler system in the event of a rapid rise in temperature. |
|
How many test sets are there for mines? |
2 |
|
What are the two test sets for mines? |
MK-503 (LEATHER CASE) MK-595 (PROGRAMMER FOR TDD) |
|
What type of fuel is used in the MK-46 Torpedo? |
OTTO fuel 2 (liquid mono-propellant) |
|
What are the symptoms of mono fuel exposure? |
Nausea, dizziness, head ache and congestion. |
|
Which quick strike mines are you QUAL/CERT in? |
MK-62, MK-63, MK-65 |
|
How much does a MK-62 mine weigh? |
500 pounds |
|
How much does a MK-63 mine weigh? |
1000 pounds |
|
How much does a MK-65 mine weigh? |
2000 pounds |
|
What arming devices is used in a MK-62 and a MK-63 quick strike mine? |
MK-32 |
|
What booster is used in a MK-62 and a MK-63 quick strike mine? |
MK-59 |
|
What fin is used when building a MK-62 mine? |
MK-16 or BSU-86 A B |
|
What fin is used when building a MK-63 mine? |
MK-12 |
|
When handling an MK-46/54 torpedo with suspension bands installed, which safety item should you look for? |
Safety bolts inserted through suspension lugs and rubber mat over suspension bands. |
|
How hot can a MK-4 signal cartridge burn? |
Approximately 2500* Fahrenheit |