Use LEFT and RIGHT arrow keys to navigate between flashcards;
Use UP and DOWN arrow keys to flip the card;
H to show hint;
A reads text to speech;
50 Cards in this Set
- Front
- Back
Falsifying or failing to keep required records, reach required evacuation levels, and knowingly release CFC and HCFC refrigerant are all violations of the clean air act. What activity with a substitute refrigerant is also a violation?
|
Venting |
|
What safety rules should a technician follow?
|
All of them |
|
Who is responsible for removing refrigerant from household refrigerators prior to disposal?
|
The final person in the disposal chain. (Scrap metal recycler, Landfill owner, etc...)
|
|
What must be done with reclaimed refrigerant before it can be legally resold?
|
Level of purity ARI standard 700
|
|
What is caused by inhaling refrigerant vapor?
|
Heart irregularities or asphyxia
|
|
Safety glasses and butyl-lined gloves should be worn during what procedures?
|
Recovery or recycling, and handling or refilling refrigerant coolers
|
|
How should systems using blended refrigerant be charged?
|
A measured charge of liquid into the high side of the system
|
|
What is the smallest container in which refrigerant may be sold to section 608 certified technicians?
|
Containers 20 pounds or larger
|
|
Which refrigerant is in HFC?
|
R-134a |
|
What is the date of the production and importation that all CFCs phased out?
|
December 31, 1995 |
|
What should be done when recovering the refrigerant from a system where the refrigerant has been improperly mixed?
|
Recover to a separate container
|
|
In addition to preventing and repairing leaks, what else should I technician do to conserve refrigerant?
|
Recover and recycle used refrigerants
|
|
When evacuating, what is the benefit of using short hoses with larger diameters?
|
Reduce emissions, reduce pressure drop, reduce evacuation/dehydration time
|
|
What breathing problem can be caused by CFC – 12?
|
Asphyxiation (Oxygen Deprivation)
|
|
What can cause liquid refrigerant to migrate to a compressor crankcase?
|
If the compressor is the coldest location in the circuit
|
|
What is a ternary blend?
|
Made by combining three different refrigerants
|
|
How do we know the chlorine in the stratosphere is coming from CFCs?
|
Increases in both Coreen and fluorine have been detected in the stratosphere. The increase in these match the increase in emissions from CFCs
|
|
What is an Azeotropic refrigerant?
|
Mixture of two or more refrigerant swear the mixture behaves like a single new refrigerant
|
|
What refrigerants have a low ODP?
|
HFC's and HCFCs
|
|
What is the recommended lubricant to use with a ternary blend?
|
Alkyl Benzene Type |
|
What is the ODP of an HFC refrigerant?
|
ZERO |
|
What releases of a CFC and HCFC are violations of the clean air act?
|
All releases
|
|
How can I speed removed from the sight glass?
|
Alcohol spray |
|
Why must only refillable cylinders be used for transport?
|
They are DOT regulated and approved
|
|
The refrigerant in the suction line is a gas that has been heated above it saturation. What is the condition called?
|
Superheated
|
|
How can a system be leak checked using it low pressure gauge?
|
After the system has been pulled down, if the pressure comes back up
|
|
Is the refrigerant leaving a condenser at a high or low pressure? What is it's state?
|
High pressure, Liquid |
|
What safety component must be used whenever dry nitrogen is used to pressurize a system?
|
a pressure regulator
|
|
What can happen to the oil in the compressor if moisture is left in an operating system?
|
It conform hydrofluoric and hydrochloric acid
|
|
What is the major cause of death involving refrigerant?
|
Oxygen deprivation
|
|
What does HFC stand for?
|
Hydrofluorocarbon
|
|
Where will we get replacements?
|
Recovery and recycling operations
|
|
What is Montreal protocol?
|
First treaty calling for reduction of the available production of CFCs
|
|
what is the likely result of heating a recovery cylinder with an open flame? |
The refrigerant in the tank decomposing into a toxic material
|
|
Which chemical in CFC refrigerants does the most damage to the ozone?
|
Chlorine
|
|
Is CFC – 12 a low or high pressure refrigerant?
|
High |
|
What does CFC stand for?
|
Chlorofluorocarbon
|
|
What is the role of the ozone layer in protecting the earth?
|
Filtering out and blocking the harmful ultraviolet radiation emitted from the sun and it helps keep the earths temperature stable
|
|
Which refrigerants are HCFCs?
|
R-22, R-123 |
|
Should you ever use a disposable cylinder for refrigerant recovery?
|
No |
|
What is the purpose of a DOT classification tag?
|
Must meet the requirements of the Code of Federal Regulations title 49 (Type of refrigerant/weight)
|
|
Do state and local laws have priority over federal law? Can they be less strict?
|
No, No |
|
How close should vacuum gauge be connected to the vacuum pump during evacuation?
|
As far away as possible
|
|
Which are CFCs?
|
R-11, 12, 113, 114 |
|
What must be done with the badly corroded relieve valve?
|
Replaced |
|
What can happen if a cylinder is overfilled?
|
It could cause a tank to rupture with extreme violence
|
|
What is the preferred instrument for detecting small leaks?
|
Electronic, Ultra Sonic
|
|
What is it about CFCs that make them more harmful in the stratosphere?
|
Higher ODP
|
|
What must be affixed to a refrigerant cylinder prior to its shipment to a reclaimer?
|
Clearly labeled with a DOT classification tag
|
|
What color are the gauges on a manifold gauge set?
|
Blue (Low side), Red (High Side) |